BUILT-IN
DOUBLE OVEN
MODEL ZDC 888
INSTRUCTION BOOKLET
Please read this instruction booklet before using the appliance
Contents
For the User
For the Installer
Important Safety Information
Description of the Oven
Controls
2
4
Installation
18
18
19
Electrical Connection
Installation
5
Main Oven
5
Lower Oven
5
Clock + End of Cooking Programmer
Before the First Use
6
7
Using the Oven
7
Using the Fan Oven (Main Oven)
Cooking Chart - Fan Oven
Using the Lower Oven (Conventional)
Grilling (Main or Lower Oven)
Cleaning the Oven
9
10
11
12
13
15
16
17
17
17
Care of catalytic liners
Something not working
Peace of Mind for 24 Months
Zanussi guarantee conditions
Service and Spare Parts
Guide to Use the Instruction Book
The following symbols will be found in the text to
guide you throughout the Instructions:
This appliance complies with the
following E.E.C. Directives:
* 73/23 - 90/683 (Low
Safety Instructions
VoltageDirective);
Step by step instructions for an operation
* 93/68 (General Directives);
* 89/336 (Electromagnetical
Compatibility Directive) .
and subsequent modifications
F
i
Hints and Tips
Environmental information
3
Description of the Oven
Lower Oven Thermostat
Control Light
Top Oven Thermostat
Control Light
End Of
Cooking
Top Oven
Lower Oven
Control Knob
Control Knob
Programmer
12
1
5
11
7
0
0
2
4
10
9
3
1 0 0
8
6
20
200
150
Grill Element
Oven Light
Shelf Supports
Fan
Main
Oven
Grease Filter
Rating Plate
Grill Element
Lower
Oven
Shelf Supports
Grilltrivet
Grill/roasting
pan
Shelf
Removable
handles
4
Controls
Main Oven
OFF
Control Knob
OvenLight-Theovenlightwillbeon
without any cooking function
0
50 - MAX Temperature adjustment for Fan
Cooking Function - This allows you
to roast or roast and bake
simultaneously using any shelf,
without flavour transference.
50
1 0 0
M A X
Grill element - The grill element will
be on
150
200
Lower Oven
OFF
Control Knob
50 - MAX Temperature adjustment for
ConventionalCookingFunction-The
heat comes from both the top and
bottom element, ensuring even
heating inside the oven.
0
50
1 0 0
Top heating element - The heat
comesfromthetopoftheovenonly.
M A X
150
200
Bottom heating element - The heat
comes from the bottom of the oven
only.
Grill element - The grill element will
be on
5
Clock + End of Cooking Programmer
This device allows you to programme the
Main Oven to switch off automatically. It
does not operate the Lower Oven.
i
12
11
7
1
5
Setting the time of the day
WINDOW
2
4
10
1) Push in completely the programmer knob
9
3
F
andatthesametimeturnitanti-clockwise,
until the clock shows the correct time of
8
day.
2) Then pull the knob outwards to its original
position.
6
KNOB
Manual function
l
Pull the programmer knob outwards and
atthesametimeturnitclockwise, untilthe
12
F
11
symbol
window.
appears in the programmer
10
Thissettingallowsyoutooperatetheovenmanually,
i. e. without any programme.
9
Semi-automatic operation
3
l
Pull the programmer knob outwards and
atthesametimeturnitclockwise, untilthe
required cooking time is displayed in the
programmer window.
75
F
4
5
6
The diagram shows the programmer set on a
cooking duration of 75 minutes.
When the cooking time is finished, the oven will
switch off automatically, and an acoustic alarm will
sound.Toswitchthealarmoff,pulltheprogrammer
knoboutwardsandatthesametimeturnitclockwise
12
11
1
until symbol
window.
is displayed in the programmer
0
6
Before the First Use
Remove all packaging, both inside and
outside the oven, before using the oven.
Before first use, the oven should be heated without
food.Duringthistime,anunpleasantodourmaybe
emitted. This is quite normal.
1. Settheprogrammertomanualfunction.
F
2. SettheMainOvencontrolknobtoMAX.
3. Open a window for ventilation.
4. Allow the oven to run empty for
approximately 45 minutes.
Thisprocedureshouldberepeatedwiththegrill
function for approximately 5-10 minutes.
The lower oven should also be heated too in the
same way using both the conventional cooking
function (MAX position) and the grill function
.
MAIN OVEN
Using the Oven
6
5
4
High
Centre
Low
}
• Always cook with the oven door
closed.
}
3
• Stand clear when opening the drop
down oven door. Do not allow it to fall
open - support the door using the door
handle, until it is fully open.
2
1
}
• The Main Oven has six shelf levels,
and is supplied with two shelves.
i
The Lower Oven has three shelf levels
and is provided with one shelf.
LOWER OVEN
Theshelfpositionsarecastedfromthe
bottom of the oven as shown in the
diagram.
3
2
1
It is important that these shelves are
correctly positioned as shown in the
diagram.
• Do not place cookware directly on the
oven base.
7
i
Hints and Tips
Condensation and steam
Whenfoodisheateditproducessteaminthesame
way as a boiling kettle. The oven vents allow some
of this steam to escape. However, always stand
back from the oven when opening the oven
door to allow any build up of steam or heat to
release.
If the steam comes into contact with a cool surface
on the outside of the oven, e.g. a trim, it will
condenseandproducewaterdroplets.Thisisquite
normal and is not a fault with the oven.
To prevent discoloration, regularly wipe away
condensation and also soilage from surfaces.
Cookware
• Use any oven proof cookware which will
withstand temperatures of 250°C.
• Baking trays, oven dishes, etc. should not be
placed directly against the grid covering the fan
at the back of the oven, or placed on the oven
base.
• Do not use baking trays larger than 30 cm x 35
cm (12 in x 14 in) as they will restrict the
circulation of heat and may affect performance.
The effects of dishes
on cooking results
Dishesandtinsvaryintheirthickness,conductivity,
colour, etc. which affects the way they transmit
heat to the food inside them.
A Aluminium, earthenware, oven glassware and
bright shiny utensils reduce cooking and base
browning.
B Enamelled cast iron, anodized aluminium,
aluminium with non-stick interior and coloured
exterior and dark, heavy utensils increase
cooking and base browning.
8
Using the Fan Oven (Main Oven)
The air inside the oven is heated by the element
aroundthefansituatedbehindthebackpanel. The
fan circulates hot air to maintain an even
temperature inside the oven.
The advantages of cooking with this function
are:
l
Faster Preheating
As the fan oven quickly reaches temperature,
it is not usually necessary to preheat the oven
although you may find that you need to allow an
extra 5-7 minutes on cooking times. For
recipes which require higher temperatures,
best results are achieved if the oven is
preheated first, e.g. bread, pastries, scones,
souffles, etc.
l Lower Temperatures
Fan oven cooking generally requires lower
temperatures than conventional cooking.
Follow the temperatures recommended in the
chart at page 10. Remember to reduce
temperatures by about 20-25°C for your own
recipes which use conventional cooking.
l Even Heating for Baking
The fan oven has uniform heating on all runner
positions. This means that batches of the
same food can be cooked in the oven at the
same time. However, the top shelf may brown
slightly quicker than the lower one.
This is quite usual. There is no mixing of
flavours between dishes.
FO 2079
FHow to Use the Fan Oven
Turn the Main Oven Control Knob clockwise to the
required temperature.
The cooling fan
During cooking the cooling fan will operate
continually.
It may run on after the oven is switched off to keep
the controls cool. This is quite normal.
THINGS TO NOTE
• The oven light will come on when the oven
function control knob is set.
NOTE
• The oven fan will operate continually during
cooking.
The action of the cooling fan will depend on how
long the oven has been used and at what tempera-
ture. It may not switch in at all at lower temperature
settings nor run on where the oven has only been
used for a short time.
• The thermostat control light will remain on until
the correct temperature is reached. It will then
cycle on and off to show the temperature is
being maintained.
9
Cooking Chart - Fan Oven
This chart is intended as a guide only. It may be necessary to increase or decrease the temperature to
suit your individual requirements. Only experience will enable you to determine the correct setting for
your personal requirements.
Food
Shelf
Cooking
Position Temp (°C)
Biscuits
Bread
Casseroles
Cakes: Small and queen
Sponges
160-190
190-220
130-140
160-170
160-170
140-150
130-140
130-140
90-100
Shelf
positions
are not
critical but
ensure
that oven
shelves
are evenly
spaced
when
more than
one is
Madeira
Rich Fruit
Christmas
Meringues
Fish
170-190
170-200
130-140
Fruit Pies and Crumbles
MilkPuddings
Pastry: Choux
Shortcrust
190-200
used.
Flaky
}
Puff
Plate Tarts
Quiches/Flans
Scones
180
170-180
210-220
160-180
Roasting:Meat & Poultry
When roasting, ensure the meat is cooked thoroughly, use a meat thermometer if preferred to check
the centre temperature has reached the required temperature (see table below).
MEAT
Beef
TEMPERATURES
Rare - 60°C
Medium - 70°C
Well Done - 80°C
Pork
Well Done - 80°C
Lamb
Medium - 70°C
Well Done - 80°C
10
UsingtheLowerOven (Conventional)
The Lower Oven can be used for conventional
cookings or grilling. The Lower oven works
independently of the Main Oven.
Hints and Tips
i
Thereshouldalwaysbeatleast2.5cm(1")between
the top of the food and the heating element. This
How to Use
the Conventional Oven
gives the best cooking results and allows room for
yeast mixtures to rise, Yorkshire puddings, etc.
When cooking cakes, pastry, scones, bread etc.,
place the tins or baking trays centrally below
When using this setting, heat comes from both
the top and bottom elements. This allows you to
element.
cook in a single level and is particularly suitable
Ensurethatfoodisplacedcentrallyontheshelfand
there is sufficient room around the baking tray/dish
to allow for maximum circulation.
for dishes which require extra base browning
such as pizzas, quiches and flans.
Gratins, lasagnes and hotpots which require
extra top browning also cook well in the
conventionaloven.
Stand dishes on suitable sized baking trays to
prevent spillage onto the oven base and to help
reduce cleaning.
Turn the Lower Oven control knob to the
required temperature.
F
The material and finish of the baking tray and
disheswillaffectthedegreeofbasebrowningofthe
food.Enamelware,dark,heavyornon-stickutensils
increase base browning. Shiny aluminium or
polished steel trays reflect the heat away and give
less base browning.
THINGS TO NOTE
l
The oven light will come on when the oven
function control knob is set.
l
The thermostat control light will remain on
until the correct temperature is reached. It will
then cycle on and off to show that temperatu-
re is being maintained.
DO NOT use the grill pan or meat tin as a baking
tray as this will increase base browning of the food.
Because of the smaller cooking space, lower
temperatures and shorter cooking times are
sometimes required.
Top oven element only
This function is suitable for finishing cooked
dishes, eg; lasagne, shepherds pie, cauliflower
cheese etc.
For economy, leave the door open for the shortest
possible time, particularly when placing food into a
preheatedoven.
Bottom oven element only
This function is particularly useful when blind-
baking pastry or cooking pizza. It may also be
used to finish off quiches or flans to ensure the
base pastry is cooked through.
The Cooling Fan
• The cooling fan will operate continually during
cooking. It may run on after the oven is
switched off to keep the controls cool. This is
quite normal.
NOTE
The action of the cooling fan will depend on how
long the oven has been used and at what tempe-
rature. It may not switch in at all at lower tempe-
rature settings nor run on where the oven has
only been used for a short time.
11
Grilling (Main or Lower Oven)
COOKING CHART
Grilling must be carried out with the oven
Cooking time depends on the thickness of the
door closed.
meat and not on its weight.
The grill pan handle must be removed
from the pan during grilling. Always use
oven gloves to remove and replace the
grill pan handle.
Type of food
Mins per side
Bacon rashers
Chicken joints
Gammon rashers
Lamb chops
2 - 5
15 - 20
5 - 8
6 - 12
10 - 15
Ensure that you support the grill pan
when removing it from the oven.
Pork chops
Sausages (turning as required)
Steaks (average thickness) Rare
10 - 12
3 - 6
6 - 10
How to Use the Grill
F
Medium
Well done 8 - 12
1. Turn the Oven Control Knob on
.
2. Adjust the grid and grill pan runner position to
allow for different thicknesses of food. Position
the food close to the element for faster cooking
and further away for more gentle cooking.
Toast
1 - 11/2
Preheat the grill on a full setting for a few minutes
before sealing steaks or toasting. Adjust the shelf
level as necessary during cooking.
During cooking, the cooling fan and the thermostat
control light will operate in the same way as
described for the fan oven function.
Hints and Tips
i
- Most foods should be placed on the grid in the
grillpantoallowmaximumcirculationofairtolift
the food out of the fats and juices. Food such as
fish, liver and kidneys may be placed directly on
the grill pan, if preferred
- Food should be thoroughly dried before grilling
to minimise splashing. Brush lean meats and
fish lightly with a little oil or melted butter to keep
them moist during cooking
- Accompaniments such as tomatoes and
mushrooms may be placed underneath the grid
when grilling meats
O
L
I
- When toasting bread, we suggest that the top
runner position is used with the grid in its 'high'
position
- The food should be turned over during cooking,
as required.
The grill element is controlled by the thermostat.
Duringcooking,thegrillcyclesonandofftoprevent
overheating.
12
CleaningtheOven
Beforecleaningalwaysallowthecoolingfan
to cool the oven down before switching off at
the electricity supply.
The oven should be kept clean at all times. A
build-up of fats or other foodstuffs could
result in a fire, especially in the grill pan.
Cleaningmaterials
Before using any cleaning materials on your oven,
check that they are suitable and that their use is
recommended by the manufacturer.
Cleaners that contain bleach should NOT be used
as they may dull the surface finishes. Harsh
abrasives should also be avoided.
External cleaning
Regularly wipe over the control panel, oven door
and door seal using a soft cloth well wrung out in
warm water to which a little washing up liquid has
been added.
To prevent damaging or weakening the door glass
panels avoid the use of the following:
• Household detergent and bleaches
• Impregnated pads unsuitable for non-stick
saucepans
• Brillo/Ajax pads or steel wool pads
• Chemical oven pads or aerosols
• Rust removers
• Bath/Sink stain removers
Clean the outer and inner door glass using warm
soapy water. Should the inner door glass become
heavily soiled it is recommended that a cleaning
product such as Hob Brite, or Bar Keepers Friend
is used.
DO NOT clean the oven door while the glass
panels are warm. If this precaution is not
observed the glass panel may shatter.
If the door glass panel becomes chipped or
has deep scratches, the glass will be
weakened and must be replaced to prevent
thepossibilityofthepanelshattering.Contact
your local Service Force Centre who will be
pleased to advise further.
Oven Cavity
The enamelled base of the oven cavity is best
cleaned whilst the oven is still warm.
Wipe the oven over with a soft cloth soaked in
warm soapy water after each use. From time to
time it will be necessary to do a more thorough
cleaning, using a proprietary oven cleaner.
DO NOT attempt to clean catalytic liners.
i
13
Oven Shelves and Shelf
Supports
To clean the oven shelves and the shelf supports,
soak in warm soapy water and remove stubborn
marks with a well wetted soap impregnated pad.
Rinse well and dry with a soft cloth.
The shelf supports can be removed for easy
cleaning(seediagram).Please,ensuretheretaining
nuts are secure when refitting the shelf support.
Grease Filter
Topreventabuild-upoffatsonthefanimpellor,the
grease filter must be fitted by clipping it over the
vents in the back panel.
To clean the grease filter
When the oven has cooled down, remove the filter
bypushingtheprotrudingtongueonthefilterupward,
and wash carefully.
Thegreasefiltershouldbecleanedaftereveryuse.
The filter may be washed in a dishwasher on a
65°C wash. If the filter is heavily soiled, place the
filter in a saucepan of water with approximately 1
teaspoon of automatic washing powder or
dishwasher powder. Bring to the boil and leave to
soak for approximately 30 minutes or longer
depending on the degree of soiling. Ensure the
solution does not boil over as it could mark your
hob.
FO 0018
Rinse filter in clear water and dry.
Remember to refit the filter before using the oven
again.
Replacing the Oven Light
If the oven bulb needs replacing, it must comply
with the following specifications:
- Electric power: 15W,
- Electric rate: 230-240 V (50 Hz),
- Resistant to temperatures of 300°C,
- Connection type: E14.
These bulbs are available from your local Service
Force Centre.
To replace the faulty bulb:
F 1. Ensuretheovenisdisconnectedfromthe
electrical supply.
2. Turn the glass cover anticlockwise.
3. Remove the faulty bulb and replace with
the new one.
4. Refit the glass cover.
FO 0287
5. Restore the electrical supply.
14
Care of catalytic liners (Main Oven)
Catalytic liners destroy splashes of food and fats
when the oven temperature is raised to around
220°C.
To aid this process it is a good idea to run the oven
foranhourortwoperweek, withoutfood, toensure
continued good performance from the Catalytic
liners.
COOKING TO REDUCE SOILAGE
Cook at the recommended temperatures. Higher
temperatures during roasting will increase soilage.
Try cooking to lower temperatures for an
increased length of time, you will save energy and
often the joint is more tender.
Use minimal, if any, extra oil or fat when roasting
meat; potatoes only require brushing with fat
before cooking. Extra fat in the oven during
roasting will increase splashing and soilage.
Hints and Tips
i
• Manual cleaning of the Catalytic liner is not
recommended. Damage will occur if soap
impregnated steel wool pads, aerosol cleaners
and any other abrasives are used.
It is NOT necessary to add water to the meat tin
when roasting. The water and the fat juices from
the joint create excessive splattering during
cooking, even at normal temperatures, as well as
causing condensation.
• Slight discoloration and polishing of the Catalytic
surface may occur in time. This does not affect
the Catalytic properties in any way.
Covering joints during cooking will also prevent
splashing onto the interior surfaces; removing the
covering for the last 20-30 minutes will allow extra
browning, if required. Some large joints and
turkeys especially benefit by this method of
cooking, allowing the joint to cook through before
the outside is overbrowned.
• Follow the recommendations below to keep
oven soilage to a minimum.
Do use the roasting tin. During roasting, the fat
from the joint will be contained beneath the trivet
and therefore prevent it from splattering onto the
'Catalytic' liner.
Cleaning the hinged grill
Both the top and the bottom ovens have been fitted
with a hinged grill element to enable you to clean
the roof of the oven easily.
Before proceeding ensure the oven is
cool and is isolated from the electricity
supply.
1) Undo the screw which holds the grill in
place (see diagram).
F
FO 0781
2) Then gently pull the grill downward to
allow access to the oven roof (see diagram).
3) Clean the oven roof with a suitable
cleaner and wipe dry before replacing the
hinged grill element.
4) Gently push up the grill element into place
and firmly screw into place the holding nut.
Ensure the grill holding nut is firmly in place to
avoid the grill falling down when in use.
FO 0778
15
Something not working
If the oven is not working correctly, please carry out the following checks, before contacting your local
Zanussi Service Centre.
IMPORTANT: If you call out an engineer to a fault listed below, or to repair a fault caused by incorrect use
or installation, a charge will be made even if the appliance is under guarantee.
SYMPTOM
SOLUTION
n The oven does not come on
u Check the oven is in manual operation and
that both a cooking function and temperature
have been selected.
u Check the oven is wired in properly, and the
socket switch or the switch from the mains
supply to the oven are ON.
u Select a temperature with the thermostat
control knob
n The oven temperature light does not come on
n The oven light does not come on
u Select a function with the oven function
control knob.
u Select a function with the oven function
control knob
u Check the light bulb, and replace it if
necessary (see "Replacing the Oven Light")
u The temperature may need adjusting
n It takes too much time to finish the dishes, or
they are cooked too fast.
u Refer to the contents of this booklet,
especially to the chapter “Using the Oven”.
u Leave dishes inside the oven no longer than
n Steam and condensation settle on the food
15-20 minutes after the cooking is completed.
and the oven cavity.
u Check the instructions for the timer.
n The timer does not work
n The oven fan is noisy
u Check the grease filter is correctly fitted.
u Check that shelves and bakeware are not
vibrating in contact with the oven back panel.
Please note that it will be necessary to provide
proof of purchase for any in-guarantee service
calls.
Ifafterallthesechecks,theovenstilldoesnotwork,
contact your local Service Force Centre.
Whenyoucontactthem,theywillneedthefollowing
information:
In-guarantee customers should ensure that
the above checks have been made as the
engineer will make a charge if the fault is not a
mechanical or electrical breakdown.
1. Your name, address and post code.
2. Your telephone number
3. Clear and concise details of the fault
4. The model and the serial number (which can be
found on the rating plate)
5. Date of purchase
16
Service and Spare Parts
CUSTOMER CARE
For general enquiries concerning your Zanussi
appliance, contact our Customer Care
Department by letter or telephone as follows:
If you require spare parts or an engineer contact
your local Service Force Centre by telephoning:
Customer Care Department
ZANUSSI
55 - 77 High Street
Slough
Berkshire - SL1 1DZ
Tel: 08705 - 727727
08705-929929
Your call will be routed to your local Service
Force Centre. For further details, please see the
accompanying Customer Care Booklet.
Peace of Mind for 24 Months
ZANUSSI GUARANTEE CONDITIONS
commercial or similar environment, plus those
which are the subject to rental agreements.
* Products of Zanussi manufacture which are not
marketed by Zanussi.
We, Zanussi, undertake that if, within 24 months of
the date of the purchase, this Zanussi appliance or
any part thereof is proved to be defective by any
reasononlyoffaultyworkmanshipormaterials, we
will, atouroption, repairorreplacethesameFREE
OFANYCHARGEforlabour, materialsorcarriage
on condition that:
* The appliance has been correctly installed and
used only on the gas and electricity supply
stated on the rating plate.
* The appliance has been used for normal
domestic purpose only, and in accordance with
the manufacturer's instructions.
* The appliance has not been serviced,
maintained, repaired, taken apart or tampered
with by any person not authorised by us.
* All service work under this guarantee must be
undertaken by a Zanussi Service Centre.
* Any appliance or defective part replaced shall
become the Company's property.
European Guarantee
If you should move to another country within
Europe then your guarantee moves with you to
your new home subject to the following
qualifications:
* The guarantee starts from the date you first
purchased your product.
* The guarantee is for the same period and to the
same extent for labour and parts as exist in the
new country of use for this brand or range of
products.
* This guarantee relates to you and cannot be
transferred to another user.
* Your new home is within the European
Community (EC) or European Free Trade
Area.
* The product is installed and used in
accordance with our instructions and is only
used domestically, i.e. a normal household
* The product is installed taking into account
regulations in your new country.
* This guarantee is in addition to your statutory
and other legal rights.
Home visits are made between 8.30am and
5.30pm Monday to Friday. Visits may be available
outside these hours, in which case a premium will
be charged.
Before you move, please contact your nearest
Customer Care centre, listed below, to give them
details of your new home. They will then ensure
that the local Service Organisation is aware of
your move and able to look after you and your
appliances.
Exclusions
This guarantee does not cover:
* Damage or calls resulting from transportation,
improper use or neglect, the replacement of
any light bulbs or removable parts of glass or
plastic.
France
Senlis
+33 (0)3 44 62 29 99
Germany Nürnberg +49 (0)911 323 2600
* Costs incurred for calls to put right an appliance
which is improperly installed or calls to
appliance outside the United Kingdom.
* Appliances found to be in use within a
Italy
Sweden
UK
Pordenone +39 (0)1678 47053
Stockholm +46 (0)8 738 79 50
Slough
+44 (0)1753 219 897
17
Installation
This oven must be installed by
qualified personnel to the relevant
British Standards.
The oven must be installed according to
the instructions supplied.
Upper oven ratings
DIMENSIONS
OF RECESS
Height
Width
Depth
878 mm.
560-570 mm.
550 mm.
Fan Oven element
Grill element
2.08 kW
1.82 kW
30 W
Convection Fan
Oven Light
DIMENSIONS
OF THE
MAIN OVEN
CAVITY
Height
Width
Depth
320 mm.
420 mm.
390 mm.
15 W
Cooling Fan
25 W
Total Rating
2.15 kW
Oven capacity 53.2 litres
Lower oven ratings
Oven element (top+bottom)
Grill element
1.89 kW
1.82 kW
15 W
DIMENSIONS
OF THE
LOWER OVEN
CAVITY
Height
Width
Depth
185 mm.
420 mm.
400 mm.
Oven Light
Oven capacity 31 litres
Total Rating
1.93 kW
4.055kW
Total connected load
ElectricalConnection
It is necessary that you install a double pole switch
betweentheovenandtheelectricitysupply(mains),
with a minimum gap of 3mm between the switch
contactsandofatypesuitablefortherequiredload
in compliance with the current rules.
Theovenisdesignedtobeconnectedto230-240V
(50Hz) electricity supply.
The oven has an easily accessible terminal block
which is marked as follows:
Letter L
Letter N
-
-
Live terminal
Neutral terminal
The switch must not break the yellow and green
earth cable at any point.
or E
-
Earth terminal
THIS OVEN MUST BE EARTHED
Thecableusedtoconnecttheoventotheelectrical
supply must comply to the specifications given
below.
Important
Afterinstallationandconnecting,thecablemustbe
placed so that it cannot at any point reach a tempe-
rature of more than 60°C above the ambient tem-
perature.
For Uk use only
Before the oven is connected, check that the main
fuse and the domestic installation can support the
load;andthatthepowersupplyisproperlyearthed.
Connection Min. size Cable/flex Fuse
via
Cable/flex type
• Cooker
Control
Circuit
6 mm2
PVC/PVC 30 A
twin and
earth
Themanufacturerdeclinesanyresponsibilityshould
these safety measures not be carried out.
For Europe use only
Min.size Cable/flex Cable / flex type Fuse
4 mm2
H05 RR-F
30 A
18
Installation
The oven must be installed according to the
instructions supplied. Any electrical work
mustbeundertakenbyaqualifiedelectrician/
competent person, in accordance with
existing rules and regulations.
Securing The Oven To The
Cabinet
1. Fit the oven into the cabinet recess,
2. Open the oven door
It is dangerous to alter the specifications or
modify the oven in any way.
3. Secure the oven to the kitchen cabinet with four
wood screws, which fit the holes provided in the
oven frame.
Please ensure that when the oven is installed it is
easily accessible for the engineer in the event of a
breakdown.
BUILDING IN
The surround or cabinet into which the oven will be
built must comply with these specifications:
- the dimensions must be as shown in the relevant
diagrams;
- the materials must withstand a temperature
increase of at least 60°C above the ambient
temperature;
- proper arrangements must be made for a
continuous supply of air to the oven to prevent the
ovenoverheating.
560
540
20
594
Dimensions of the oven
50
600
560 min
Recess required
19
35670-3803
03/00
|